Light Vehicle
PM Schedule

• Home
• About FLEET
  • FLEET Contacts
  • Services
  • Leasing and Fleet Management
    • Lease FAQ
    • Management Costs
    • Fleet Management at FLEET
    • Fleet Management Best Practices
  • Repair Facility
  • Outside Repairs
• Radio Services
• Customer Information
  • FLEET News
    • Vehicle Needs a New Home
    • E85 FLEET Flash
    • Fuel Vendor Rankings
    • Gas Containers
    • Reducing Fuel Consumption
    • Air Bag Safety
    • Anti-lock Braking Systems
  • Drivers Frequently Asked Questions
  • Licence Plate Replacement
  • Ambulance Information
    • Ambulance FAQ
  • Accident Information
  • 2009 Vehicle Ordering Guide
  • Our Location
• Vendor Information
  • Light Vehicle PM Schedule
  • Ambulance PM Schedule
• Vehicle Auction
  • Auction List
• Renting Vehicles
• Related Information

 

VEHICLE MAINTENANCE CHECKLIST EVERY 4 MO. OR 4,000 KMS	SERVICE	A	A	A	A	A	B	A	A	A	A	A	C	REVERT TO SERVICE A, SLOT 1
	SLOT	1	2	3	4	5	6	7	8	9	10	11	12
During any PM Service, all body damage should be reported to FLEET immediately	KM x 1000	4	8	12	16	20	24	28	32	36	40	44	48
Change engine oil & filter		X	X	X	X	X	X	X	X	X	X	X	X
Clean interior & exterior if requested (wash & vacuum)		X	X	X	X	X	X	X	X	X	X	X	X
Check exhaust - Visual		X	X	X	X	X	X	X	X	X	X	X	X
Check air filter - replace if required		X	X	X	X	X	X	X	X	X	X	X	X
Visually inspect & adjust tire pressure to spec.		X	X	X	X	X	X	X	X	X	X	X	X
Check steering & suspension - Visual		X	X	X	X	X	X	X	X	X	X	X	X
Check horn, windshield wipers and lights for proper operation		X	X	X	X	X	X	X	X	X	X	X	X
Inspect belts, hoses, battery terminals, fluid levels, heater controls, and advise if service required		X	X	X	X	X	X	X	X	X	X	X	X
Lube all locks, latches and hinges (door, hood & trunk)		X	X	X	X	X	X	X	X	X	X	X	X
Check CV Boots - Visual if applicable		X	X	X	X	X	X	X	X	X	X	X	X
Inspect all brakes (remove wheels)							X						X
Rotate tires if required							X						X
Repack front or rear wheel bearings							X						X
Replace fuel filter and service PCV system													X
Road Test							X						X
Tuneup - Replace spark plugs (if necessary), service emission system, inspect & replace ignition system components as necessary. To include scan for service codes.													X
Automatic Transmission Tuneup - change filter and fluid													X
Check front suspension & steering components - Align wheels & aim headlights if required													X
4 x 4 Vehicles Only:
Service front hubs													X
Change differential fluid & transfer case fluid													X

Winterizing Procedures (to be done every fall):

1. Check Block Heater.
2. Flush cooling system if required.
3. Install frost shields if requested.
4. Complete AVR check.
5. Check anti-freeze (should be good to -40C).

The above Preventive Maintenance Program was developed by the Fleet Vehicles Agency (FLEET) to optimize the life and dependability of your vehicle. Following this program will ensure that your vehicle will remain safe and dependable for its entire life. All repairs and services must be authorized by FLEET. Authorization can be obtained by contacting us at (204) 945-5288 within Winnipeg or by calling 1-800-363-6693 outside of Winnipeg.

Home >